FAQ – Vanliga frågor
För närvarande finns denna sida endast på engelska. Svensk version kommer inom kort.
Why should I reproof my outdoor garments?
Outdoor garments are complex constructions made up of a variety of materials. Through use and laundering, these materials are subject to degradation. Especially the water repellent finish (DWR) is relatively vulnerable as it is applied in the last stage of fabric processing and is the layer that protects the fabric not only from wetting, but also to some extent to wear and tear. This means the DWR degrades faster than the textile fibres themselves. In addition, good water repellence is important for supporting membrane function, as a wet outer fabric reduces the moisture transmission rate of the membrane. By reapplying a water repellent finish, you restore all the properties of this finish and extend the useful life of your garment. As a result, garments would in the long run profit from a regular reproofing treatment over waiting until the factory applied DWR is washed out completely.
What is the difference between OrganoTex® Spray-On and OrganoTex® Wash-In?
Both products rely on the same technology and use a 3D lotus effect to provide water repellence. The products are optimised to suit the different application methods. Based on the garment and circumstances, you can pick the product of your choice. Please, follow the instructions on the label carefully, or check out our instruction videos here.
Does OrganoTex® Wash-In set on the inside of my garment?
Since the garment is immersed in a solution containing Wash-In, some product may also set on the inside, depending on the material. One may think that it is undesirable to get waterproofing on the inside of the garment. However, our safe products are not film-forming, and therefore allow for maintained breathability.
Do technical membranes change their properties when treated with OrganoTex®?
There is a wide range of technical membranes on the market, and new membrane technologies are introduced continuously. However, as a rule of thumb, for all hydrophobic or microporous (e.g., Gore-Tex®) membranes both Wash-In and Spray-On can be used. For hydrophilic membranes (e.g., SympaTex®), where the function relies on a chemical moisture transportation property, Spray-On is preferred, as it can be applied more specifically on the outer fabric only, whereas Wash-In might change the chemical property underlying the function of the membrane. Although what can be seen generally, is that even hydrophilic membranes do usually not tend to show a practical loss in functionality when they were subject to an impregnation with Wash-In.
Do I need to tumble dry my garments after applying OrganoTex® products?
Not necessarily, as our technology does not require to heat to be activated, which means that you can expect a restored water repellence on your garments by just letting them dry at room temperature. However, warm drying in a tumble dryer or drying cabinet increases the durability and often boosts the effect of your freshly applied OrganoTex® treatment; so, when care instructions allow, we would still recommend running a short cycle at low temperature. Alternatively, you can apply some heat with a hair dryer or on a heating element or by hanging it in strong sunlight. Warm drying also improves the functionality on a major part of the factory applied finishes (DWR) on the market.
Approximately how many wash cycles does OrganoTex® last?
This is mainly dependent on the fibre type and how much of the factory applied water repellent finish (DWR) is left. In general, one could expect the treatment to last between 5-10 laundry cycles. It is always recommended to use a technical detergent to increase the useful life of the treatment. On synthetic fabrics the treatment is often retained longer than on fabrics made from natural fibres.
Why technical detergent?
Commonly, classical detergents are packed with surface actives and other functional molecules that help water reach hydrophobic dirt. They may be left in your functional finish, where they will act as a channel for water molecules reaching the fabric, causing it to wet. Residues are often a result of excessive foam formation during laundering, as foam is hard to rinse out from your washing machine. If you see foam left on your garment after washing, it is recommended to carry out additional rinsing cycles until no foam can be seen on the outer fabric surface. To prevent this from happening, it is highly recommended to use a technical detergent, like OrganoTex® BioCare, on your outdoor garments. These are not only milder for functional finishes and the environment, but they are also developed to minimise foaming and thereby the amount of residue left after running a normal laundry cycle.
How often should I wash my outdoor garments?
Generally, quite frequently, even when not visible dirty, sweat and dirt might be sitting in the membrane reducing its functionality. Washing the garments with a technical laundry detergent cleans out the pores in the membrane and removes dirt that inhibit the water repellent finish on the outer fabric. Moreover, it removes sweat that has gathered under for example seam tapes. Over time sweat residue can decrease adhesion in the taped seams, so keeping your garments clean is the way to increase their useful life.
How does Wool & Down wash restore wool’s natural properties?
Our combined Wool & Down wash is equipped with an optimised amount of lanolin, which is natural wool grease. While washing, this grease refats the fibres in wool, while not altering the properties of down. The detergent is even equipped with lemon eucalyptus essential oil, that refreshes the fabric deeply.
What does it mean that your products are biobased?
This means that OrganoTex® is made from renewable resources, such as agricultural waste streams, and other forms of biomass. An important step towards the bioeconomy, where we are no longer depending on fossil fuels to create high-performance materials and functionalities. USDA BioPreferred® is a certification body that certifies based on tests measuring the share of renewable carbon in our products.
Is OrganoTex® vegan?
Since we are marketing a unique range of biobased products, this is a legitimate question. Currently, our products contain ingredients derived from agricultural rest streams, which may also include streams from animal origin. Therefore, we cannot put a vegan claim on our products.
What does it mean that your products are “readily biodegradable according to OECD 301”?
The OECD 301 method is a quick but harsh test that assesses what happens with chemicals when they are exposed to microorganisms that commonly occur in surface waters. The test requires substances to be eaten up by nature within a 10-day window. A reference known to biodegrade is added for comparison. When chemistry passes this test, it is classified as readilybiodegradable. Sometimes producers call their products biodegradable without referring to a test method. By successfully testing OrganoTex® to this type of harsh biodegradation tests we have strong proof of rapid biodegradation.